中文版 | English

服务热线:0571-89804615

  • 电动托盘搬运车的保养维护?
  • 本站编辑:杭州东桦叉车配件有限公司发布日期:2022-03-09 15:55 浏览次数:

保养应每天进行一次,主要内容是保持车身表面清洁,将蓄电池表面清理干净,检查电源线是否牢固,链条松紧是否正常。

每周进行一次,保养内容除日常保养内容外,应重点检查各部件工作情况是否正常,各紧固件是否有松动,链条松紧是否适当,链条接头连接销是否弯扭,内外门架上下运动是否正常,液压接头是否漏油,机械部分是否有不正常的磨损,电器部分是否有不正常的温升和火花等,如果发现有不正常现象应及时调整和清除。

每隔三个月进行一次,首先是检查蓄电池电解液的比重是否适当,电池接线端子是否干净,否则必须将电解液的比重按规定调整好,将接线端子清理干净,并涂上少许凡士林,正确地拧紧。而后检查各电器接头是否可靠,开关是否正常,并检查电器绝缘是否正常。

每半年进行一次,主要内容是将驱动轮的传动齿轮和轴承加润滑油,给各转动关节加润滑油,同时检查各紧固件是否牢固,各车轮是否转动灵活,货叉升降是否正常。

每隔12个月进行一次,检查油缸是否处于正常状态,是否有内漏和外漏,液压接头、液压胶管是否可靠无泄漏现象。液压油是否清洁,一般在12个月更换一次液压油。

The maintenance shall be carried out once a day. The main contents are to keep the body surface clean, clean the battery surface, and check whether the power line is firm and whether the chain tightness is normal.

The maintenance shall be carried out once a week. In addition to the daily maintenance, it shall focus on checking whether the working conditions of all parts are normal, whether the fasteners are loose, whether the chain tightness is appropriate, whether the connecting pin of chain joint is bent and twisted, whether the up and down movement of inner and outer door frames is normal, whether the hydraulic joint leaks oil, and whether the mechanical part is abnormally worn, Whether there is abnormal temperature rise and spark in the electrical part. If any abnormal phenomenon is found, it shall be adjusted and removed in time.

Once every three months, first check whether the specific gravity of the battery electrolyte is appropriate and whether the battery terminals are clean. Otherwise, the specific gravity of the electrolyte must be adjusted according to the regulations, the terminals must be cleaned, coated with a little vaseline and tightened correctly. Then check whether the electrical connectors are reliable, whether the switches are normal, and whether the electrical insulation is normal.

Once every six months, the main content is to add lubricating oil to the transmission gear and bearing of the driving wheel and to each rotating joint. At the same time, check whether the fasteners are firm, whether the wheels rotate flexibly and whether the lifting of the fork is normal.

Every 12 months, check whether the oil cylinder is in normal condition, whether there is internal and external leakage, and whether the hydraulic joint and hydraulic hose are reliable and free of leakage. Whether the hydraulic oil is clean, generally replace the hydraulic oil once every 12 months.